Product ID:54403000 MIL-C-22750D COMP A 16440 GRAY
MSDS Date:08/01/1989
FSC:8010
NIIN:00-497-5880
Kit Part:Y
MSDS Number: BRQDD

KOP-COAT INC

436 7TH AVENUE
PITTSBURGH, PA 15219-1818
US

Emergency Phone: 800-553-5631, CHEMTREC 800-424-9300

Info Phone: 800-556-7737, 412-227-2155

Preparer: C.A. HOPE

Cage: 00297

KOP-COAT INC

PITTSBURGH, PA 15219-1818 US

Telephone: 800-553-5631, CHEMTREC 800-424-9300

Cage: 00297

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 10-15%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 10-15%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 40-45%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

BISPHENOL A DIGLYCIDYL ETHER RESIN

Fraction By Weight: 30-35%

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF HIGH
CONCENTRATIONS OF MIST OR VAPOR MAY CAUSE CENTRAL NERVOUS SYSTEM
DEPRESSION AND RESPIRATORY IRRITATION. CONTACT WITH EYES MAY CAUSE
IRRITATION. INGESTION MAY CAUSE GI TRACT D ITURBANCES. CHRONIC:
PROLONGED OR REPEATED EXPOSURE MAY CAUSE SKIN IRRITATION OR
DEFATTING.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED: COUGHING, WHEEZING, SHORTNESS OF
BREATH, HEADACHE, WEAKNESS, INCOORDINATION, DIZZINESS, NAUSEA,
VOMITING. EYES: REDNESS, BURNING SENSATION, TEARING, PAIN. SKIN:
REDNESS, CRACKING, BLISTERING. INGESTED: NAUSEA, VOMITING,
DIARRHEA, DIZZINESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALED: REMOVE TO FRESH AIR. IF BREATHING IS STOPPED OR
DIFFICULT; ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION AS NEEDED.
EYES: FLUSH WITH LOTS OF WATER FOR 15 MINUTES. SEE DOCTOR. SKIN:
WASH WITH SO AP AND WATER. IF SYMPTOMS PERSIST, SEE DOCTOR.
INGESTED: DO NOT INDUCE VOMITING! IF CONSCIOUS, GIVE 1-2 OUNCES OF
ACTIVATED CHARCOAL IN WATER. GET IMMEDIATE MEDICAL ATTENTION.

Flash Point:35.0F,1.7C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, OR FOAM
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. USE WATER TO COOL FIRE EXPOSED CONTAINERS
WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR, MAY TRAVEL
TO AN IGNITION SOURCE, IGNITE AND FLASHBACK. CLOSED CONTAINERS MAY
EXPLODE IF EXPOSED TO FIRE.

Spill Release Procedures:STOP LEAK IF POSSIBLE. ELIMINATE ALL SOURCES
OF IGNITION. VENTILATE AREA. ABSORB WITH INERT MATERIAL AND PLACE
IN A CLEAN, MARKED CONTAINER FOR LATER DISPOSAL. PRODUCT RELEASED
MUST BE REPORTED TO NAT IONAL RESPONSE CENTER 800-424-8802.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE DESIGNED TO
COMPLY WITH OSHA 1910.106. KEEP IN A CLOSED, LABELED CONTAINER.
POTECT FROM PHYSICAL DAMAGE.
Other Precautions:GROUND AND BOND CONTAINERS PROPERLY DURING TRANSFER
OPERATIONS. DO NOT USE PRESSURE TO EMPTY CONTAINERS. KEEP AWAY FROM
SOURCES OF IGNITION AND INCOMPATIBLE MATERIALS. DISCARD
CONTAMINATED FOOTWEAR.

Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR EMERGENCY
OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED AIR
RESPIRATOR OR SCBA, AS REQUIRED. USE IN ACCORDANCE WITH 29 CFR
1910.134.
Ventilation:USE ADEQUATE (EXPLOSION-PROOF) MECHANICAL VENTILATION OR
LOCAL EXHAUST TO MAINTAIN EXPOSURE BELOW REGULATORY LIMIT.
Protective Gloves:NEOPRENE
Eye Protection:SAFETY GLASSES
Other Protective Equipment:DEPENDING ON WORKING CONDITIONS: CLOTHING TO
PREVENT PROLONGED OR REPEATED SKIN CONTACT.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health

HCC:F2
Vapor Density:>1 (AIR=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREY LIQUID; SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HMIS: AVOID STRONG OXIDIZING AGENTS, HEAT,
SPARKS, AND OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
UPON THERMAL DECOMPOSITION.

Waste Disposal Methods:REPORTABLE QUANTITY IS 100 POUNDS. DISPOSE OF IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. DISPOSE OF AS
AN IGNITABLE HAZARDOUS WASTE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.